[Engine oil classroom] The generation and solution of sludge carbon deposit!

https://www.sdrboil.com/

 [Engine oil classroom] The generation and solution of sludge carbon deposit!

The engine oil class started today. Does your car have insufficient power, increased fuel consumption, engine idling, and increased engine noise after driving a certain mileage? If the answer is yes, it means that your car may be suffering from sludge or carbon deposition; sludge and carbon deposition are the two major killers of contemporary engines. Today, technical engineers Zhang Gong will answer questions about sludge carbon deposition.

01

Q: How is carbon sludge produced?

For vehicles fueled by gasoline or diesel, it is difficult for the fuel to burn completely. The gasoline that is not completely burned will adhere to the interior of the engine combustion chamber. The gasoline contains colloid, so carbon deposition will occur under high temperature environment; some unburned fuel will enter the crankcase and mix with the oil to produce carbon deposition.

Extended maintenance, failure to replace air filters in time, insufficient combustion caused by long-term ultra-high speed or frequent low-speed driving in urban areas, and high engine temperatures will lead to the formation of carbon deposits and sludge inside the engine. Long-term use of low-end inferior lubricating oil is also one of the reasons for the formation of sludge deposits.

02

Q: What kind of engine fault phenomenon can sludge carbon deposit cause?

Accumulation of sludge carbon deposit to a certain extent will lead to oil channel blockage, insufficient pressure, knocking abnormal sound, serious even cylinder pulling or serious wear of bearing pads, locking and other mechanical accidents.

03

Q: What are the formation factors of sludge carbon? How should this be resolved?

If a large amount of sludge and carbon deposit are found inside the engine during oil change, this must be the accumulated result of a long time, such as long-term use of mineral oil or semi-synthetic engine oil, and at least one maintenance is not timely before, and the vehicle is driven at low speed for a long time, overloaded or used in a bad environment, a large amount of sludge and carbon deposit will be produced.

It can be said that once the engine is running, sludge and carbon deposit will inevitably be produced, which requires engine blood-oil, which has the effect of decomposing carbon deposit and sludge, and will bring certain sludge and carbon deposit into the oil pan along with the circulation of oil, so as to be discharged when changing the oil.

Good oil, can effectively inhibit the formation of sludge carbon, the use of fully synthetic oil in line with national standards, and according to the use of regular replacement requirements, is not due to the oil itself to produce a lot of sludge, carbon, because fully synthetic oil than mineral oil, semi-synthetic oil, has more excellent oxidation resistance and cleaning ability.

Ribang lubricating oil, through the use of exclusive research and development of scientific formula, so that lubricating oil has excellent clean dispersion performance, fuel economy, anti-wear, load bearing performance, energy saving and environmental protection indicators to provide the best quality protection for the engine.